P0487 code meaning
EGR Throttle Control Circuit A/Open
Powertrain system Generic code P04xx codes Check engine light
What P0487 means
Exhaust gas recirculation (EGR) routes part of the exhaust back into the intake to lower combustion temperature and NOx. The EGR throttle is a regulating flap ahead of the intake manifold on diesels: by closing partly it lowers manifold pressure below exhaust back pressure so that enough exhaust is recirculated, and it also helps filter regeneration and shuts off air at engine stop. It is usually a DC motor with position sensor. GM and Ford report this flap under P02E0 ff; no manufacturer document available to us uses this code. P0487 means its drive circuit is open or has a general circuit fault, detected by the output stage. The flap then stays open, so the EGR rate cannot be raised enough and filter regeneration may be blocked.
P0487 at a glance
- Check engine lightYes, usually on
- Emissions testCan fail
- Limp modePossible
- Repair difficultyMedium, DIY possible
- Typical labor0.5 to 2 hours
- Clears after repairAfter a drive cycle
Symptoms of P0487
- Check engine light on
- Loss of power or limp mode possible
- Shaking when the engine is switched off
- Filter regeneration does not complete
Common causes of P0487
- Most likelyConnector at the flap corroded or loose, wire open
- PossibleFlap actuator motor faulty (winding open)
- Less likelyPneumatic version: vacuum converter faulty
- Less likelyDriver in the engine module
Check the most likely causes first. Replacing parts by guesswork is the most expensive way to clear a code.
Parts involved
EGR throttle valveThrottle actuatorActuator wiringEngine control module
What each part of P0487 means
| P | Powertrain system: engine, fuel system, ignition, emissions and transmission. |
| 0 | Generic code: it means the same on every make (SAE standard). |
| 4 | Area: auxiliary emission controls (catalytic converter, EGR, EVAP). |
| 87 | The exact fault in that area. |
What to do next
- Note P0487 and any other codes stored with it: several codes together often point to one cause.
- Check for loose connectors and damaged wiring around the parts the code names.
- Check open recalls for your car: some faults are fixed for free by the dealer. Enter your VIN.
- Clear the code only after the repair. If it comes back, the fault is still there.
Buying a used car? Scan it for stored codes before you pay. A recently cleared memory can hide a problem.
Questions about P0487
What does P0487 mean?
P0487 means "EGR Throttle Control Circuit A/Open". Exhaust gas recirculation (EGR) routes part of the exhaust back into the intake to lower combustion temperature and NOx. It is a generic code, so it means the same on every make.
Is it safe to drive with P0487?
Drive gently and only to a workshop. With P0487 the car can go into limp mode (reduced power) to protect itself.
Will P0487 fail an emissions test?
Yes, it can. P0487 is emissions-related, so most inspection programs fail a car while it is stored or while the check engine light is on.
How hard is P0487 to fix?
Difficulty: medium. A typical repair takes 0.5 to 2 hours of work. A careful DIY repair is possible with basic tools and a scanner.
Will P0487 clear itself after the repair?
After the repair the car has to complete a drive cycle (a mix of city and highway driving) before the test runs again. Until then the readiness monitor shows "not ready", which can fail an inspection.