P04E5 code meaning
EGR Temperature Sensor D Circuit
Powertrain system Generic code P04xx codes Check engine light
What P04E5 means
Exhaust gas recirculation (EGR) routes part of the exhaust back into the intake to lower combustion temperature and NOx. The code standard allows up to four EGR temperature sensors, A to D – for example before and after the cooler, or in the high- and low-pressure circuits; which is which depends on the maker. Sensor D is the fourth of them, usually an NTC whose low voltage means hot. P04E5 is its general circuit fault, conceivable on systems with high- and low-pressure EGR and two sensors per circuit. No manufacturer document available to us uses sensor D – GM, Ford and FCA use at most A to C – so the description follows CARB's requirement to check input circuits for continuity and range. EGR then uses a substitute value or is switched off.
P04E5 at a glance
- Check engine lightYes, usually on
- Emissions testCan fail
- Limp modeNot expected
- Repair difficultyMedium, DIY possible
- Typical labor0.5 to 1.5 hours
- Clears after repairAfter a drive cycle
Symptoms of P04E5
- Check engine light on
- Usually no change in driving (EGR on a substitute value or off)
- Possibly EGR flow or cooler codes (P0401, P2457)
Common causes of P04E5
- Most likelyWire or connector fault
- PossibleSensor faulty
- Less likelyEngine module
Check the most likely causes first. Replacing parts by guesswork is the most expensive way to clear a code.
Parts involved
EGR temperature sensor dSensor wiringEngine control module
What each part of P04E5 means
| P | Powertrain system: engine, fuel system, ignition, emissions and transmission. |
| 0 | Generic code: it means the same on every make (SAE standard). |
| 4 | Area: auxiliary emission controls (catalytic converter, EGR, EVAP). |
| E5 | The exact fault in that area. |
What to do next
- Note P04E5 and any other codes stored with it: several codes together often point to one cause.
- Check for loose connectors and damaged wiring around the parts the code names.
- Check open recalls for your car: some faults are fixed for free by the dealer. Enter your VIN.
- Clear the code only after the repair. If it comes back, the fault is still there.
Buying a used car? Scan it for stored codes before you pay. A recently cleared memory can hide a problem.
Questions about P04E5
What does P04E5 mean?
P04E5 means "EGR Temperature Sensor D Circuit". Exhaust gas recirculation (EGR) routes part of the exhaust back into the intake to lower combustion temperature and NOx. It is a generic code, so it means the same on every make.
Is it safe to drive with P04E5?
Usually yes, for a short time, if the check engine light is steady and the car drives normally. If the light flashes or the car runs badly, stop and have it checked.
Will P04E5 fail an emissions test?
Yes, it can. P04E5 is emissions-related, so most inspection programs fail a car while it is stored or while the check engine light is on.
How hard is P04E5 to fix?
Difficulty: medium. A typical repair takes 0.5 to 1.5 hours of work. A careful DIY repair is possible with basic tools and a scanner.
Will P04E5 clear itself after the repair?
After the repair the car has to complete a drive cycle (a mix of city and highway driving) before the test runs again. Until then the readiness monitor shows "not ready", which can fail an inspection.